How to remove and install the water pump on Volvo 740?

To take out the water pump on a 2.3L 4-cylinder, you need to disconnect the negative of battery cable, turn on the heater control to its maximum heat and take away the expansion tank cap. Located in the engine block and radiator, open the draincocks and remove the coolant into an appropriate container, then close the draincocks. Next detach radiator shroud and radiator fan, then the lower radiator hose to the water pump. Repeatedly push the retaining bolt of the coolant pipe underneath the exhaust manifold back, should the need arise. The next task is the removal of drive belts, water pump pulleys, the water pump bolts, washers, and nuts to withdraw the water pump assembly. To install, clean the contact surfaces of both the gasket with care, apply new gasket and O-rings covered with coolant, and put a thin coating of gasket sealer on the water pump. Install the water pump and then make sure to tighten the retaining bolts to 11-15 ft. lbs. (15-20 Nm) in cross cross pattern. Installation of coolant pipe and lower radiator hose, accessory drive belts, water pump pulley, fan and shroud should be reinstalled. The negative battery cable should be reconnected, the cooling system should be filled with coolant, the engine should be started until it reaches a normal operating temperature, the leakage should be inspected, and further addition of coolant should be mustered. In the 2.8L 6-cylinder engine, loosen 2.8L negative battery, empty the cooling system, and take off the overflow tank cap. Unscrew the radiator hoses and, where provided, the transmission cooler lines at the radiator. Take the fan shroud, radiator, fan, the hoses to water pump to respective cylinders heads, fan belts and water pump pulley. Take the hose off the water pump at the looseness at the back of the water pump and take it out of the block. Install thermal sender, temperature sensor, thermostat cover, thermostat and rear pump cover on the new pump then installing it and tightening the bolts to 11-15 ft. lbs. (15-20 Nm). Put on the clamps, water pump pulley, fan belts, hoses, fan, shroud, and radiator, re-check the transmission cooler connections (where installed), and install the intake manifold (as needed). The negative battery cable should be reconnected, and the radiator should be filled with coolant when necessary, then the engine is started, and leaks should be checked. In case of 2.9L 6-cylinder engine, unmount the negative battery cable, drain the cooling fluid, lift the timing belt and the bolts of the water pump to lift the water pump off. Wipe the mating surfaces and install a new water pump using the new gasket, tighten the mounting bolts up to 15 ft. lbs. (20 Nm) and then re-install the timing belt, empty the cooling system, re-connect the negative battery cable and then start the engine, look to see that it does not leak. With the 2.3L and 2.4L 5-cylinder engines, discharge the pressure on the fuel system, disconnect negative battery cable, lift and hold vehicle up, and remove splashguard. Drain system 20 drain the cooling system and loosen the fuel line clips, expansion tank, front timing cover and accessory belts. To access the water pump, first remove the timing belt and the water pump retaining bolts to remove the water pump cleaning the area of intersection between the cylinder block and the water pump. Install the new water pump and gasket, and tighten the bolts to 15 ft. lbs. (20 Nm) and then replacement the timing belt and the parts that have been removed previously. Re-connect the negative battery connector, add the cooling system, start the engine till it reaches normal working temperature, and examine the side rims, refilling them when needed.

How to remove and refit the water pump and timing belt on Volvo V40?

To remove the timing belt, first start by draining the cooling system. Next slacken and remove the pump retaining bolts then remove the water pump from the cylinder block, recover and discard the gasket, which will need to be replaced for refitting. For the GDI engine, sealant is used instead of a regular gasket. When refitting, make sure that the mating surfaces of the water pump and cylinder block are clean and dry and for the GDI engine make sure that all traces of old sealant are removed. Fit the new gasket and, for GDI engine, apply 3mm bead of sealant on the inner surface of the water pump and then locate the pump in the cylinder block. Refit pump retaining bolts and tighten to specified torque, sealant and tightening bolts for GDI engine. Finally, re-attach the timing belt and refill the cooling system when done.

Genuine Volvo Water Pump

H2O Pump

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

30 Water Pumps found

View related parts
Volvo Water Pump Part Number: 30751700
$187.85 MSRP: $284.62
You Save: $96.77 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- 850 | 1993-1997 | Base, GLT, R, T-5, T-5R, Turbo | 5 Cyl 2.3 L GAS, 5 Cyl 2.4 L GAS
- C30 | 2008-2013 | T5, T5 R-Design | 5 Cyl 2.5 L GAS
- C70 | 2006-2013, 1998-2004 | Base, T5 | 5 Cyl 2.3 L GAS, 5 Cyl 2.4 L GAS, 5 Cyl 2.5 L GAS
- S40 | 2000-2011 | 2.4i, Base, i, LSE, T5, T5 R-Design | 4 Cyl 1.9 L GAS, 5 Cyl 2.4 L GAS, 5 Cyl 2.5 L GAS
- S60 | 2012-2016, 2001-2009 | 2.4, 2.4T, 2.5T, 2.5T AWD, AWD, Base, R, T5, T5 Inscription Platinum, T5 Inscription Premier, T5 Platinum, T5 Premier, T5 Premier Plus | 5 Cyl 2.3 L GAS, 5 Cyl 2.4 L GAS, 5 Cyl 2.5 L GAS
- S60 Cross Country | 2016 | T5 Platinum | 5 Cyl 2.5 L GAS
- S70 | 1998-2000 | AWD, Base, GLT, GLT SE, T5 | 5 Cyl 2.3 L GAS, 5 Cyl 2.4 L GAS
- S80 | 2004-2006 | 2.5T, 2.5T AWD | 5 Cyl 2.5 L GAS
- V40 | 2000-2004 | Base, LSE | 4 Cyl 1.9 L GAS
- V50 | 2005-2011 | 2.4i, i, T5, T5 R-Design | 5 Cyl 2.4 L GAS, 5 Cyl 2.5 L GAS
View More
View related parts
Volvo Water Pump Part Number: 31219000
$187.85 MSRP: $284.62
You Save: $96.77 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- S80 | 2007-2010 | 3.2, T6 | 6 Cyl 3.0 L GAS, 6 Cyl 3.2 L GAS
- V70 | 2008-2010 | 3.2 | 6 Cyl 3.2 L GAS
- XC60 | 2010 | 3.2, T6, T6 R-Design | 6 Cyl 3.0 L GAS, 6 Cyl 3.2 L GAS
- XC70 | 2008-2010 | 3.2, T6 | 6 Cyl 3.0 L GAS, 6 Cyl 3.2 L GAS
- XC90 | 2007-2014 | 3.2, 3.2 R-Design | 6 Cyl 3.2 L GAS
View More
View related parts
Volvo Water Pump Part Number: 31293303
$187.85 MSRP: $284.62
You Save: $96.77 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- S60 | 2011-2016 | T6, T6 Polestar, T6 R-Design, T6 R-Design Platinum | 6 Cyl 3.0 L GAS
- S80 | 2010-2015 | 3.2, T6 | 6 Cyl 3.0 L GAS, 6 Cyl 3.2 L GAS
- V60 | 2015-2016 | T6 Polestar, T6 R-Design, T6 R-Design Platinum | 6 Cyl 3.0 L GAS
- XC60 | 2010-2016 | 3.2, 3.2 R-Design, T5, T5 Platinum, T5 Premier, T6, T6 Ocean Race, T6 Platinum, T6 Premier, T6 R-Design, T6 R-Design Platinum | 4 Cyl 2.0 L GAS, 5 Cyl 2.5 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.2 L GAS
- XC70 | 2010-2015 | 3.2, T6 | 6 Cyl 3.0 L GAS, 6 Cyl 3.2 L GAS
View More
View related parts
Volvo Auxiliary Pump Part Number: 31368042
$187.85 MSRP: $284.62
You Save: $96.77 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump; Auxiliary Pump
Fits the following Volvo Models:
- XC60 | 2018-2021 | T5 Inscription, T5 Momentum, T5 R-Design, T6 Inscription, T6 Momentum, T6 R-Design | 4 Cyl 2.0 L GAS
View related parts
Volvo Water Pump Part Number: 8694630
$187.85 MSRP: $284.62
You Save: $96.77 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Coolant Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- S80 | 2003-2005 | 2.9, T6, T6 Premier | 6 Cyl 2.9 L GAS
- XC90 | 2003-2005 | T6 | 6 Cyl 2.9 L GAS
View related parts
Volvo Water Pump Part Number: 32382367
$224.44 MSRP: $340.05
You Save: $115.61 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Coolant Pump; Water Pump, Water Pump Assembly
- Replaced by: 32441161
Fits the following Volvo Models:
- S60 | 2022-2023 | B5 Core, B5 Inscription, B5 Momentum, B5 Plus, B5 R-Design, B5 Ultimate, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge R-Design Expression, T8 Recharge Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV), 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- S90 | 2022-2023 | B6 Inscription, B6 Momentum, B6 Plus, B6 R-Design, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- V60 Cross Country | 2023 | B5 Plus, B5 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- V90 Cross Country | 2022-2023 | B6, B6 Plus, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- XC40 | 2023 | B4 Plus, B4 Ultimate, B5 Core, B5 Plus, B5 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- XC60 | 2022-2023 | B5 Core, B5 Inscription, B5 Momentum, B5 Plus, B5 R-Design, B5 Ultimate, B6 Inscription, B6 Momentum, B6 R-Design, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- XC90 | 2023 | B5 Core, B5 Plus, B6 Core, B6 Plus, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
View More
View related parts
Volvo Auxiliary Pump Part Number: 31657307
$262.67 MSRP: $397.98
You Save: $135.31 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump 2601; Auxiliary Pump, Auxiliary Pump Bracket
- Replaced by: 32324817
Fits the following Volvo Models:
- S90 | 2022-2023 | B6 Inscription, B6 Momentum, B6 Plus, B6 R-Design, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- V60 Cross Country | 2023 | B5 Plus, B5 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- V90 Cross Country | 2022-2023 | B6, B6 Plus, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
View More
View related parts
Volvo Auxiliary Pump Part Number: 32249376
$262.67 MSRP: $397.98
You Save: $135.31 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump; Auxiliary Pump
- Replaces: 32222617
Fits the following Volvo Models:
- XC40 | 2023 | B4 Plus, B4 Ultimate, B5 Core, B5 Plus, B5 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
View related parts
Volvo Water Pump Part Number: 30731384
$289.26 MSRP: $438.27
You Save: $149.01 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Coolant Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- S80 | 2007-2010 | V8 | 8 Cyl 4.4 L GAS
- XC90 | 2005-2011 | V8, V8 Ocean Race, V8 Sport | 8 Cyl 4.4 L GAS
View related parts
Volvo Auxiliary Pump Part Number: 30776243
$389.02 MSRP: $589.41
You Save: $200.39 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump Kit; Auxiliary Pump
Fits the following Volvo Models:
- XC90 | 2005-2011 | V8, V8 Ocean Race, V8 Sport | 8 Cyl 4.4 L GAS
View related parts
Volvo Water Pump Part Number: 31493259
$392.34 MSRP: $594.45
You Save: $202.11 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Auxiliary Pump
Fits the following Volvo Models:
- S90 | 2022-2023 | B6 Inscription, B6 Momentum, B6 Plus, B6 R-Design, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- V60 Cross Country | 2023, 2020-2021 | B5 Plus, B5 Ultimate, T5 | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- V90 Cross Country | 2022-2023 | B6, B6 Plus, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- XC40 | 2023 | B4 Plus, B4 Ultimate, B5 Core, B5 Plus, B5 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
- XC90 | 2023 | B5 Core, B5 Plus, B6 Core, B6 Plus, B6 Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV)
View More
View related parts
Volvo Water Pump Part Number: 32382249
$635.91 MSRP: $979.83
You Save: $343.92 (36%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Coolant Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- S60 | 2015-2023 | Polestar, Recharge R-Design, T5, T5 Dynamic, T5 Inscription, T5 Inscription Platinum, T5 Inscription Premier, T5 Momentum, T5 Platinum, T5 Premier, T5 Premier Plus, T5 R-Design, T5 R-Design Special Edition, T6, T6 Inscription, T6 Momentum, T6 Platinum, T6 Premier Plus, T6 R-Design, T6 R-Design Platinum, T8 Inscription, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge R-Design Expression, T8 Recharge Ultimate | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- S60 Cross Country | 2017-2018 | T5 | 4 Cyl 2.0 L GAS
- S80 | 2015-2016 | T5, T5 Platinum, T6 | 4 Cyl 2.0 L GAS, 6 Cyl 3.0 L GAS
- S90 | 2017-2023 | B6 Inscription, B6 Momentum, B6 Plus, B6 R-Design, B6 Ultimate, T5 Inscription, T5 Momentum, T6 Inscription, T6 Momentum, T6 R-Design, T8 Inscription, T8 Momentum, T8 R-Design, T8 Recharge Inscription, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV), 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- V60 | 2015-2023 | Polestar, T5, T5 Dynamic, T5 Inscription, T5 Momentum, T5 Platinum, T5 Premier, T5 Premier Plus, T5 R-Design, T6 Inscription, T6 Momentum, T6 R-Design, T6 R-Design Platinum, T8 Polestar, T8 Recharge Polestar | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- V60 Cross Country | 2020-2022, 2017-2018 | T5, T5 Platinum | 4 Cyl 2.0 L GAS
- V90 | 2018-2021 | T5 Inscription, T5 R-Design, T6 Inscription, T6 R-Design | 4 Cyl 2.0 L GAS
- V90 Cross Country | 2017-2021 | T5, T6, T6 Ocean Race | 4 Cyl 2.0 L GAS
- XC40 | 2019-2022 | T4 Inscription, T4 Momentum, T4 R-Design, T5 Inscription, T5 Momentum, T5 R-Design | 4 Cyl 2.0 L GAS
- XC60 | 2015-2023 | T5, T5 Dynamic, T5 Inscription, T5 Momentum, T5 Platinum, T5 Premier, T5 R-Design, T6, T6 Dynamic, T6 Inscription, T6 Momentum, T6 Ocean Race, T6 Platinum, T6 Premier, T6 R-Design, T8 Inscription, T8 Momentum, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
View More
View related parts
Volvo Water Pump Part Number: 8694626
$112.71 MSRP: $133.07
You Save: $20.36 (16%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Coolant Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- 850 | 1993-1994 | Base, GLT, Turbo | 5 Cyl 2.3 L GAS, 5 Cyl 2.4 L GAS
- 960 | 1992-1994 | Base | 6 Cyl 2.9 L GAS
View related parts
Volvo Water Pump Part Number: 8694627
$124.10 MSRP: $146.52
You Save: $22.42 (16%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Coolant Pump Kit; Engine Water Pump; Water Pump, Water Pump Assembly
Fits the following Volvo Models:
- S80 | 1999-2005 | 2.9, T6, T6 Premier | 6 Cyl 2.8 L GAS, 6 Cyl 2.9 L GAS
View related parts
Volvo Water Pump Part Number: 32222255
$237.98 MSRP: $309.88
You Save: $71.90 (24%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Auxiliary Pump, Pump Assembly
Fits the following Volvo Models:
- S60 | 2019-2023 | Recharge R-Design, T8 Inscription, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge R-Design Expression, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- S90 | 2020-2023 | B6 Inscription, B6 Momentum, B6 Plus, B6 R-Design, B6 Ultimate, T6 Inscription, T6 Momentum, T6 R-Design, T8 Inscription, T8 R-Design, T8 Recharge Inscription, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV), 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- V60 | 2020-2023 | T5 Inscription, T5 Momentum, T5 R-Design, T6 Inscription, T6 Momentum, T6 R-Design, T8 Polestar, T8 Recharge Polestar | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- XC60 | 2018-2023 | T8 Inscription, T8 Momentum, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- XC90 | 2020-2023 | T8 Inscription, T8 Momentum, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
View More
View related parts
Volvo Water Pump Part Number: 31368312
$237.98 MSRP: $309.88
You Save: $71.90 (24%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Engine Auxiliary Water Pump; Engine Water Pump; Auxiliary Pump, Water Pump
- Replaced by: 32324816
Fits the following Volvo Models:
- S60 | 2019-2023 | Recharge R-Design, T8 Inscription, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge R-Design Expression, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- S90 | 2022-2023 | B6 Inscription, B6 Momentum, B6 Plus, B6 R-Design, B6 Ultimate, T8 Recharge Inscription, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L MILD HYBRID EV-GAS (MHEV), 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- V60 | 2019-2021 | T5 Inscription, T5 Momentum, T5 R-Design, T6 Inscription, T6 Momentum, T6 R-Design, T8 Polestar, T8 Recharge Polestar | 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- XC60 | 2018-2023 | T8 Inscription, T8 Momentum, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- XC90 | 2016-2023 | T8 Excellence, T8 Inscription, T8 Momentum, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
View More
View related parts
Volvo Water Pump Part Number: 32249706
$237.98 MSRP: $309.88
You Save: $71.90 (24%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Auxiliary Pump
- Replaces: 32222252
Fits the following Volvo Models:
- S60 | 2019-2023 | Recharge R-Design, T8 Inscription, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge R-Design Expression, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- V60 | 2020-2023 | T8 Polestar, T8 Recharge Polestar | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- XC60 | 2020-2023 | T8 Inscription, T8 Momentum, T8 Polestar, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge Polestar, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
- XC90 | 2020-2023 | T8 Inscription, T8 Momentum, T8 R-Design, T8 Recharge Core, T8 Recharge Inscription, T8 Recharge Inscription Expression, T8 Recharge Plus, T8 Recharge R-Design, T8 Recharge Ultimate | 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV)
View More
View related parts
Volvo Pump Part Number: 32257969
$228.47 MSRP: $297.48
You Save: $69.01 (24%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump; Pump
- Replaces: 32208569
Fits the following Volvo Models:
- XC40 Recharge | 2021-2022 | Base, Core, Plus, Ultimate | BATTERY EV (EV/BEV)
View related parts
Volvo Pump Part Number: 32135208
$237.98 MSRP: $309.88
You Save: $71.90 (24%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump; Pump
Fits the following Volvo Models:
- C40 Recharge | 2022-2023 | Core, Plus, Ultimate | BATTERY EV (EV/BEV)
- XC40 Recharge | 2023 | Core, Plus, Ultimate | BATTERY EV (EV/BEV)
View related parts
Volvo Pump Part Number: 32339380
$237.98 MSRP: $309.88
You Save: $71.90 (24%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Water Pump; Pump
- Replaces: 32208793, 32339379, 32324007
Fits the following Volvo Models:
- C40 Recharge | 2022-2023 | Core, Plus, Ultimate | BATTERY EV (EV/BEV)
- XC40 Recharge | 2021-2023 | Base, Core, Plus, Ultimate | BATTERY EV (EV/BEV)

| Page 1 of 2 |Next >

1-20 of 30 Results

Volvo Water Pump Parts and Q&A

Water Pump
271975
Q: How to remove and install the water pump on Volvo 740?
A:
To take out the water pump on a 2.3L 4-cylinder, you need to disconnect the negative of battery cable, turn on the heater control to its maximum heat and take away the expansion tank cap. Located in the engine block and radiator, open the draincocks and remove the coolant into an appropriate container, then close the draincocks. Next detach radiator shroud and radiator fan, then the lower radiator hose to the water pump. Repeatedly push the retaining bolt of the coolant pipe underneath the exhaust manifold back, should the need arise. The next task is the removal of drive belts, water pump pulleys, the water pump bolts, washers, and nuts to withdraw the water pump assembly. To install, clean the contact surfaces of both the gasket with care, apply new gasket and O-rings covered with coolant, and put a thin coating of gasket sealer on the water pump. Install the water pump and then make sure to tighten the retaining bolts to 11-15 ft. lbs. (15-20 Nm) in cross cross pattern. Installation of coolant pipe and lower radiator hose, accessory drive belts, water pump pulley, fan and shroud should be reinstalled. The negative battery cable should be reconnected, the cooling system should be filled with coolant, the engine should be started until it reaches a normal operating temperature, the leakage should be inspected, and further addition of coolant should be mustered. In the 2.8L 6-cylinder engine, loosen 2.8L negative battery, empty the cooling system, and take off the overflow tank cap. Unscrew the radiator hoses and, where provided, the transmission cooler lines at the radiator. Take the fan shroud, radiator, fan, the hoses to water pump to respective cylinders heads, fan belts and water pump pulley. Take the hose off the water pump at the looseness at the back of the water pump and take it out of the block. Install thermal sender, temperature sensor, thermostat cover, thermostat and rear pump cover on the new pump then installing it and tightening the bolts to 11-15 ft. lbs. (15-20 Nm). Put on the clamps, water pump pulley, fan belts, hoses, fan, shroud, and radiator, re-check the transmission cooler connections (where installed), and install the intake manifold (as needed). The negative battery cable should be reconnected, and the radiator should be filled with coolant when necessary, then the engine is started, and leaks should be checked. In case of 2.9L 6-cylinder engine, unmount the negative battery cable, drain the cooling fluid, lift the timing belt and the bolts of the water pump to lift the water pump off. Wipe the mating surfaces and install a new water pump using the new gasket, tighten the mounting bolts up to 15 ft. lbs. (20 Nm) and then re-install the timing belt, empty the cooling system, re-connect the negative battery cable and then start the engine, look to see that it does not leak. With the 2.3L and 2.4L 5-cylinder engines, discharge the pressure on the fuel system, disconnect negative battery cable, lift and hold vehicle up, and remove splashguard. Drain system 20 drain the cooling system and loosen the fuel line clips, expansion tank, front timing cover and accessory belts. To access the water pump, first remove the timing belt and the water pump retaining bolts to remove the water pump cleaning the area of intersection between the cylinder block and the water pump. Install the new water pump and gasket, and tighten the bolts to 15 ft. lbs. (20 Nm) and then replacement the timing belt and the parts that have been removed previously. Re-connect the negative battery connector, add the cooling system, start the engine till it reaches normal working temperature, and examine the side rims, refilling them when needed.
Water Pump
30751700
Q: How to remove and refit the water pump and timing belt on Volvo V40?
A:
To remove the timing belt, first start by draining the cooling system. Next slacken and remove the pump retaining bolts then remove the water pump from the cylinder block, recover and discard the gasket, which will need to be replaced for refitting. For the GDI engine, sealant is used instead of a regular gasket. When refitting, make sure that the mating surfaces of the water pump and cylinder block are clean and dry and for the GDI engine make sure that all traces of old sealant are removed. Fit the new gasket and, for GDI engine, apply 3mm bead of sealant on the inner surface of the water pump and then locate the pump in the cylinder block. Refit pump retaining bolts and tighten to specified torque, sealant and tightening bolts for GDI engine. Finally, re-attach the timing belt and refill the cooling system when done.