How should upper and lower radiator hoses, along with heater hoses, be checked and replaced on Volvo 760?

Upper and lower radiator hoses, as well as heater hoses, should be inspected for deterioration, leaks and loose clamps at least every 15,000 miles (24,000 km) - periodic inspections are recommended during the early spring and at the start of fall or winter during other maintenance. A quick visual inspection can show weakened hoses that can result in breakdowns if they are left in place. When checking hoses, ensure that the engine and cooling system are cold and look for any cracks, rot or collapse; replace those with weak or swollen spots. Start by disconnecting the negative battery cable and stripping the radiator pressure cap, being careful not to get burned by hot coolant or steam. Position a clean container under the radiator and open the drain to allow the cooling system to drain appropriately, considering that pets may have an affinity for antifreeze, which may be fatal. Loosen the hose clamps on both ends of the hose to be replaced, twist, pull and slide the hose off the fitting without damaging the connection. If the hose is stuck, use a single edged razor blade to make a cut down the stuck portion without cutting too deep. Clean both hose mounting connections and look at the clamps for replacement if necessary. For installation, dip the ends on the new hose in clean engine coolant, slip the clamps over the replacement hose and secure them at least 4 inches (6.35mm) from the ends of the replacement hose making sure they are past the raised bead of the connector. Close the radiator or engine drains and fill the cooling system with clean drained coolant or a suitable combination of ethylene glycol and water. If available, install a pressure tester to check for leaks and if not, run the engine to normal operating temperature and then check for leaks around the hose fittings and connections, being extremely careful around moving or hot engine parts.

Genuine Volvo 760 Radiator Hose

Radiator Hose Tube

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

15 Radiator Hoses found

View related parts
Volvo 760 Overflow Hose Part Number: 981376
$14.86 MSRP: $19.03
You Save: $4.17 (22%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose; Radiator Hose; Coolant Pipe; Overflow Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1985 | GLE | 6 Cyl 2.4 L DIESEL
View related parts
Volvo 760 Hose Part Number: 3531884
$48.21 MSRP: $56.46
You Save: $8.25 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Engine Coolant Reservoir Hose; Coolant Pipe; Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1987-1990 | Base, GLE | 4 Cyl 2.3 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 1257347
$24.68 MSRP: $28.90
You Save: $4.22 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Coolant Pipe; Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1985 | GLE | 6 Cyl 2.4 L DIESEL
View related parts
Volvo 760 Lower Hose Part Number: 1378106
$30.43 MSRP: $35.63
You Save: $5.20 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Coolant Hose; Coolant Pipe; Lower Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1986 | Base, GLE | 4 Cyl 2.3 L GAS, 6 Cyl 2.4 L DIESEL, 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 270615
$30.43 MSRP: $35.63
You Save: $5.20 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Radiator Coolant Hose; Coolant Pipe; Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984 | GLE | 4 Cyl 2.3 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 3536130
$37.88 MSRP: $44.35
You Save: $6.47 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Output: Radiator Hose; Coolant Hose; Coolant Pipe; Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1985-1987 | Base, GLE | 4 Cyl 2.3 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 464969
$39.04 MSRP: $45.71
You Save: $6.67 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Coolant Pipe; Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1987 | GLE | 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Lower Hose Part Number: 270616
$42.48 MSRP: $49.74
You Save: $7.26 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Radiator Coolant Hose; Coolant Pipe; Lower Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984 | GLE | 4 Cyl 2.3 L GAS
View related parts
Volvo 760 Lower Hose Part Number: 3514982
$58.55 MSRP: $68.56
You Save: $10.01 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Radiator Coolant Hose; Coolant Pipe; Hose, Lower Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1988-1990 | GLE | 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Lower Hose Part Number: 6842129
$58.55 MSRP: $68.56
You Save: $10.01 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Radiator Coolant Hose; Coolant Pipe; Hose, Lower Hose, Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1987-1990 | Base, GLE | 4 Cyl 2.3 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 3514981
$24.68 MSRP: $28.90
You Save: $4.22 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Radiator Coolant Hose; Coolant Pipe; Hose, Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1987-1990 | GLE | 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Hose Part Number: 9155496
$29.27 MSRP: $34.27
You Save: $5.00 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Engine Coolant Reservoir Hose; Coolant Pipe; Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1988-1990 | GLE | 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 3514629
$31.57 MSRP: $36.97
You Save: $5.40 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Coolant Hose; Coolant Pipe; Hose, Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1990 | Base, GLE | 4 Cyl 2.3 L GAS, 6 Cyl 2.4 L DIESEL, 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Lower Hose Part Number: 464970
$34.32 MSRP: $40.18
You Save: $5.86 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Coolant Pipe; Lower Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1987 | GLE | 6 Cyl 2.8 L GAS
View related parts
Volvo 760 Upper Hose Part Number: 1328849
$47.64 MSRP: $55.79
You Save: $8.15 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Hose; Coolant Pipe; Lower Hose, Upper Hose
- Warranty: This genuine part is guaranteed by Volvo's factory warranty.
Fits the following Vehicles:
- 1984-1985 | GLE | 6 Cyl 2.4 L DIESEL

Volvo 760 Radiator Hose

OEM parts are the only choice for top quality and real functionality. They pass strict checks, and they match Volvo's factory specs, so installation is easy. If you need new Radiator Hose and you want quality and fit. You will find both here. Our site has a wide range of OEM Volvo 760 parts. The prices are unbeatable, allowing you to get value for money. Each genuine 760 Radiator Hose comes with the manufacturer's warranty. That gives you peace of mind. We ship fast to your door. Order today, and enjoy a smooth, no-hassle upgrade with parts that fit right.

Volvo 760 Radiator Hose Parts and Q&A

Hose
3531884
Q: How should upper and lower radiator hoses, along with heater hoses, be checked and replaced on Volvo 760?
A:
Upper and lower radiator hoses, as well as heater hoses, should be inspected for deterioration, leaks and loose clamps at least every 15,000 miles (24,000 km) - periodic inspections are recommended during the early spring and at the start of fall or winter during other maintenance. A quick visual inspection can show weakened hoses that can result in breakdowns if they are left in place. When checking hoses, ensure that the engine and cooling system are cold and look for any cracks, rot or collapse; replace those with weak or swollen spots. Start by disconnecting the negative battery cable and stripping the radiator pressure cap, being careful not to get burned by hot coolant or steam. Position a clean container under the radiator and open the drain to allow the cooling system to drain appropriately, considering that pets may have an affinity for antifreeze, which may be fatal. Loosen the hose clamps on both ends of the hose to be replaced, twist, pull and slide the hose off the fitting without damaging the connection. If the hose is stuck, use a single edged razor blade to make a cut down the stuck portion without cutting too deep. Clean both hose mounting connections and look at the clamps for replacement if necessary. For installation, dip the ends on the new hose in clean engine coolant, slip the clamps over the replacement hose and secure them at least 4 inches (6.35mm) from the ends of the replacement hose making sure they are past the raised bead of the connector. Close the radiator or engine drains and fill the cooling system with clean drained coolant or a suitable combination of ethylene glycol and water. If available, install a pressure tester to check for leaks and if not, run the engine to normal operating temperature and then check for leaks around the hose fittings and connections, being extremely careful around moving or hot engine parts.